SUMMER SERVICES
PREVENTATIVE MAINTENANCE SERVICE
Call For Pricing
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Check for fuel, oil & water leaks
*Inspect belts, hoses & clamps
*Top off coolant & fluids
*Change spark plugs (carburetor engines only)
*Inspect distributor cap & rotor (replace if needed)
*Change fuel filters
*Confirm shift & throttle operations
*Check A/C output (generators)
-
*Check battery connections
*Run engine up in temperature, confirm water flow
*Check telltale hose for blockage & clean
*Test charging system
*Confirm shift & throttle operations
*Inspect for fuel, oil & water leaks
*Change spark plugs
*Replace fuel filters
*Replace compressor air filter on Optimax engines
*Change/top-off gear oil
*Top off power trim & tilt fluid
*Grease prop shaft splines
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Check for water, fuel & oil leaks
*Inspect belts, hoses & clamps
*Confirm shift & throttle operations
*Change primary & secondary fuel filters
*Purge fuel system of all air
*Top off coolant & fluids
*Check A/C output (generators)
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Check telltale hose for blockage & clean
*Test charging system
*Confirm shift & throttle operations
*Inspect for fuel, oil & water leaks
*Change spark plugs
*Replace fuel filters
*Change/top-off gear oil
*Top off power trim & tilt fluid
*Grease prop shaft splines
-
*Remove and reinstall outdrive
*Inspect u-joint, bellows & gimbal bearing
*Check engine alignment
*Change/top off gear oil
*Grease fittings & prop shaft splines
TUNE UP SERVICES
-
*Check battery connections, top off engine oil
*Run engine up in temperature, confirm water flow
*Load test starting battery & test charging system
*Replace spark plugs
*Compression test all cylinders
*Replace spark plug wires (if needed)
*Replace distributor cap & rotor
*Adjust timing to specifications (if applicable)
*Check idle air control operation (EFI models)
*Check & adjust carburetor if needed
*Check & lube choke operations (if applicable)
*Replace all fuel filters
*Check all belts & hoses
*Top-off fluids & inspect for leaks
*Confirm & lube shift & throttle operations
-
*Check battery connections, load test starting battery
*Run engine up in temperature, confirm water flow
*Test charging system
*Compression test all cylinders
*Replace spark plugs
*Replace all fuel filters
*Replace compressor air filter on Optimax engines
*Check all fuel hoses & fittings
*Check & adjust carburetors (if applicable)
*Synchronize linkages to timing marks
*Check timing marks & adjust if needed
*Confirm & lube shift & throttle operations
*Change gear oil
*Top off power trim & tilt fluid
*Grease all fittings & prop shaft splines
*Computer diagnostic scan on E.C.M. (if applicable)
-
*Check battery connections, load test starting battery
*Top off engine oil
*Run engine up in temperature, confirm water flow
*Test charging system
*Compression test all cylinders
*Replace spark plugs
*Check all fuel hoses & fittings
*Replace all fuel filters
*Check & adjust carburetors (if applicable)
*Inspect timing belt, replace if needed
*Confirm & lube shift & throttle operations
*Change gear oil
*Top off power tilt & trim fluid
*Grease all fittings & prop shaft splines
*Computer diagnostic scan on E.C.M. (if applicable)
OIL CHANGES
We service all outboard, inboard, I/O, and sterndrives
Oil Disposal Fee………..…$2.50 Per Quart
FRESH WATER SYSTEM COMMISSIONING
*Flush nontoxic antifreeze from pumps & lines
*Pressurize system & check for leaks
*Inspect hot water tank & fittings for leaks
*Flush ice makers (if applicable)
*Test all sinks & spigots
*Prime freshwater toilets (if applicable)
BOTTOM PAINT
Includes Labor & Materials
*Remove loose debris from hull
*Wipe down with acetone
*Tape off waterline
*Apply one coat ablative antifouling paint
Does not include removing and resetting on trailer.
Note: Specialty Paints are Available at an Additional Cost
-
Remove loose debris from hull, wipe down with acetone,
tape off waterline, apply one coat ablative antifouling paint
Specialty Paints Available at Additional Cost
Does not include removing & resetting boat on trailer
-
Call to schedule evaluation and estimate
Includes marking & taping new waterline, dewaxing, primer
coat & 2 coats ablative antifouling paint
Specialty Paints Available at Additional Cost
Does not include removing and resetting boat on trailer
-
Call for pricing.
GELCOAT and FIBERGLASS REPAIRS
Gelcoat Scratch Repair
Chip & Gouge Repair
Spider Crack Repair
Dock Rash Repair
Oxidation Removal
Color Matching
Finish Sanding & Buffing
Custom Console Modifications
Speaker Pod Fabrication
Storage Compartment Fabrication
Hatch & Lid Repair/Replacement
Swim Platform Repair
Livewell & Baitwell Repair
Mounting Pad Reinforcement
Storm Damage Repair
Docking Damage Repair
Trailer Damage Repair
Collision Repair
Insurance Claim Estimates
Pre-Sale Repairs
Hardware Resealing
Through-Hull Repair
Engine Bracket Reinforcement
Repower Transom Reinforcement
Water Intrusion Repair
Preventative Maintenance
Hourly Labor Plus Materials
WASH, COMPOUND and WAX
Full Exterior Boat Wash
Deck & Non-Skid Cleaning
Hull Cleaning
Interior Wipe Down
Window & Isinglass Cleaning
Stainless Steel Cleaning
Compartment Cleaning
Hand Wax Application
Machine Wax Application
Premium Marine Paste Wax
UV Protection Coating
Sealant Application
Water Spot Removal
Long-Term Finish Protection
Heavy Oxidation Removal
Gelcoat Restoration
Multi-Step Compound Process
High-Speed Machine Buffing
Color Restoration
Scratch Removal
Faded Surface Renewal
EQUIPMENT
100 Ton Railway
*(Includes 10 Days on Rails, Water and Electricity)
Crane
Work Boat
-
From Badger Island Marina to IMS
Includes Blocks and Stands
-
At Island Marine Service
-
Boat Left On Hydraulic Trailer
SUMMER STORAGE
JUNE 1ST- SEPTEMBER 30TH
Boats at IMS Yard
Trailers
**All trailers will require working tongue jacks**
2% of hourly labor costs will be added to invoice for shop supplies and consumables